Partial Replacement Of Fine Aggregate In Recycled Concrete

Effect of Waste Plastic as Partial Replacement of Aggregate

conventional aggregate up to certain 20% gives strength with in permissible limit. Modified concrete casted using plastic aggregate as a partial replacement to coarse aggregate shows 10 % it could be satisfy as per IS codes. Density of concrete is reducing after 20% replacement of coarse aggregates in a concrete

Research Paper BEHAVIOR OF PARTIAL REPLACEMENT OF FINE

BEHAVIOR OF PARTIAL REPLACEMENT OF FINE AGGREGATE WITH CRUMB RUBBER CONCRETE Nithiya P1* and Portchejian G 1 Concrete is one of the most widely used construction materials in the world. Cement and aggregate, which are the most important constituents used in concrete production, are then vital materials needed for the construction industry.

(PDF) Utilization of Recycled Glass Waste as Partial Replacement

Rahim et al. (2015) research the utilization of recycled glass waste as partial replacement of fine aggregate in concrete production and they found that the optimum percentage of glass waste that ...

PAPER OPEN ACCESS Related content The

of recycled waste tyres as a partial replacement for fine aggregate in the production of concrete. The main objective of this paper is to evaluate the level of durability of concrete containing rubber from recycled tyres as fine 2.1

Walnut Shell for Partial Replacement of Fine

2017/07/04 · Walnut Shell for Partial Replacement of Fine Aggregate in Concrete: Modeling and Optimization Ibtisam Kamal1,*, Aryan Far Sherwani2, Ammar Ali3, Ausama Khalid2, Ibrahim Saadi2, Ari Harbi2 1Soran University, Kurdistan2

Walnut Shell for Partial Replacement of Fine Aggregate in

However, another study demonstrated that using sawdust as partial replacement of fine aggregate up to 25% will contributes to reduction in sawdust waste generation without adversely affecting concrete strength [30]. Close relations were predicted by using groundnut shells for partial replacement of fine aggregate in concrete [27].

Waste glass powder as partial replacement of cement for

The fine aggregate used for the study was prepared according to graded sand requirements ASTM C778 ().Properties of fine aggregate are shown in Table 1, Table 2.For the flow test sand grading was prepared as per EN 196-1 ().

(PDF) Recycled glass as a partial replacement for fine aggregate

The object of this research work is to study the effect of using recycled glass waste, as a partial replacement of fine aggregate, on the fresh and hardened properties of Self-Compacting Concrete ...

STUDY ON PARTIAL REPLACEMENT OF FINE AGGREGATE WITH

work, partial replacement of fine aggregate by recycled plastic granules at 4%, 8% and 12% in M30 grade of concrete containing steel and polypropylene fibers was done. The steel fibers were added at 0.5%, 1% and 1.5% by volume of concrete. Various steel and polypropylene

Recycling of waste glass as a partial replacement for fine

Using waste glass as a partial replacement for fine aggregate did not produce any notable change in the concrete color. • Testing results indicated that partial replacement of sand with waste glass powder reduces the ASR expansion. •

What are the materials that can be replaced as fine

2/11/2017 · Replace fine aggregates or natural sand ? As if you replace fine aggregates from concrete it will become “No fines Concrete “ used for specific purposes to prepare pervious media. If you want to replace natural sand on the other hand there are ple...

Recycled glass replacement as fine aggregate in self

Nov 11, 2013 · The strength reduction of concrete in different glass replacement ratios is not remarkable, thus it can be produced SCC with waste glass as fine aggregate in a standard manner. Recycled glass replacement as fine aggregate in self-compacting concrete | SpringerLink

Compressive Strength of Concrete with Recycled Glass as

The control samples are Grade 30 ordinary Portland cement concrete (OPCC) containing 100% natural sand and coarse aggregate. The recycled glass concretes contain 70% natural fine aggregate + 30% size 300 micron crushed glass (Sample 2), and 70% fine aggregate + 15% size 300 micron crushed glass + 15% size greater than 300 micron crushed glass ...

partial replacement of fine aggregate by glass powder in concrete

partial replacement of fine aggregate by glass powder, is on going project in india, glass powder enhance the strength of the concrete Slideshare uses cookies to improve functionality and performance, and to provide you with relevant advertising.

Utilization of Recycled Glass Waste as Partial Replacement

The properties of concretes containing glass dust waste as fine aggregate were investigated in this study. Glass dust waste was used as a partial replacement for sand at 10%, 20% and 50 % of concrete mixes. Compression

What are the effects of using demolished material in concrete as partial replacement of aggregate

RCA(recycled concrete aggregate) * Cost Savings – Homeowners and contractors alike can save some money by working with RCA. Because the materials are less expensive to produce, you’ll be able to lay down a firm base or foundation for a fraction o...

Use of Recycled Tires as Partial Replacement of Coarse

reefs, erosion control, and as aggregate in asphalt and concrete. The use of recycled tires as partial aggregate in concrete has been considered for several years. Previous research conducted show dramatic changes in the mechanical properties of concrete when rubber is introduced to the mix [2-11]. A tire is a composite

PARTIAL REPLACEMENT OF FINE AGGREGATE BY

• Firstly, replacement of fine aggregate is done by 5% in the concrete. • Then, replacement of fine aggregate is increased to 10% in the concrete. • And, At last, 15% fine aggregate is replaced with crumb rubber in the concrete.

PARTIAL REPLACEMENT OF FINE AGGREGATE BY GLASS POWDER IN

could be used an alternate material for natural sand as partial replacement. In brief, successful utilization of glass as fine aggregate will turn this waste material into a valuable resource. In this research we are going to evaluate the utility of glass powder as a partial replacement of fine aggregate in concrete.

use of waste material as partial replacement for concrete mix

Ceramic waste can be used in concrete to improve its strength and other durability factors. Ceramic waste can be used as a partial replacement of cement or as a partial replacement of fine aggregate sand as a supplementary addition to achieve different properties of concrete.

EXPERIMENTAL INVESTIGATION ON PARTIAL REPLACEMENT

EXPERIMENTAL INVESTIGATION ON PARTIAL REPLACEMENT OF WASTE PLASTIC IN CONCRETE Arivalagan.S ... The suitability of recycled plastics as fine aggregate in concrete and its advantages are discussed here. The initial questions arising of the bond strength and the heat of hydration regarding plastic aggregate ... Preparation of recycled plastic ...

To Study the Properties of Concrete with Partial Replacement

indicate significant improvement in the strength properties of plain concrete by the inclusion of up to 80 Copper slag as replacement of fine aggregate sand , and can be effectively used in structural concrete. Also as percentage of Copper Slag increased the density of concrete increased. The workability

Investigation of recycled poly-ethylene terephthalate (PET

Investigation of recycled poly-ethylene terephthalate (PET) as partial replacement of coarse aggregate in concrete Md. Jahidul Islam1, Iftekhar Alam Dipta2 and Md. Rahat2 1Department of Civil Engineering Military Institute of Science and Technology, Dhaka, Bangladesh 2Department of Civil and Environmental Engineering

The Effect of Fine and Coarse Recycled Aggregates on Fresh

Today, the use of recycled aggregates as a substitute for a part of the natural aggregates in concrete production is increasing. This approach is essential because the resources for natural aggregates are decreasing in the world. In the present study, the effects of recycled concrete aggregates as a partial replacement for fine (by 50%) and coarse aggregates (by 100%) were examined in the self ...

Recycled Plastics as Coarse Aggregate for Structural Concrete

Coarse aggregate, plastic aggregate, partial replacement, volumetric substitution, grade substitution. I. INTRODUCTION: Concrete is the most widely used man made construction material in the world and its second only to water as the most utilized substance in the planet.

Partial Replacement of Cement and Fine Aggregate by using

partial replacement of cement and fine aggregate for rigid pavement in road construction. In developed countries use of mineral admixtures such as fly ash, silica fume, plastic waste and rise husk ash etc is already adopting to prepare concrete. This includes commercial application on large scale either for addition or for replacement of cement.

(PDF) A Project Report on " BEHAVIOUR OF CONCRETE BY PARTIAL

A Project Report on " BEHAVIOUR OF CONCRETE BY PARTIAL REPLACEMENT OF COARSE AGGREGATE WITH RECYCLED PLASTIC GRANULES "

Partial replacement of cement and fine aggregate by

Aug 08, 2014 · • In 3rd set of cubes, the maximum compressive strength obtained for 28 days is 42.57 N/mm2 with the replacement of 20% of Cement by fly ash and 10% of fine aggregate by glass aggregate. • iv)In 4th set of cubes, the maximum compressive strength obtained for 28 days is 32.44 N/mm2 with the replacement of 30% of Cement by fly ash and 20% of ...

(PDF) Use of Recycled Tire in Concrete for Partial Aggregate

PDF | On Jan 1, 2016, Muhammad B. Waris and others published Use of Recycled Tire in Concrete for Partial Aggregate Replacement | Find, read and cite all the research you need on ResearchGate ...

AN EXPERIMENTAL STUDY ON PARTIAL ADDITION OF RECYCLED RUBBER

experimental procedure adopting recycled rubber tyres as a partial replacement for coarse aggregate to manufacture concrete tyres. Pretreating has of one with sodium hydroxide solution to modify its surface and interfacial transition zone allowing the rubber to adhere with cement paste. The cycle tyres were taken and its surface were

What are the materials that can be replaced as fine aggregate

Feb 11, 2017 · Replace fine aggregates or natural sand ? As if you replace fine aggregates from concrete it will become “No fines Concrete “ used for specific purposes to prepare pervious media.

What are the advantages of partial replacement of fine aggregate in concrete

Reduction of cost and utilisation of waste materials. Sand is becoming extremely expensive now. Materials such as artificial sand are being introduced into the market at large scale that reduce the cost burden of river sand on concrete considerabl...

Related Posts